Can i raise the pump in the sump 6 inches or so and therefore pump more water per cycle. The 1/3HP model is just over 10 inches tall and the 1/2HP model is just over 12 inches tall. the pump is not turning off. Sort of worried it might fail and flood the basement. The 507 will pump 900 GPH at 10 feet and the 510 will pump 1320 GPH at 10 feet. ", Designed for rapid heat dissipation and extended life, Offers years of reliable, trouble-free operation, Oil-filled and hermetically sealed to prevent overheating, Assures maximum protection for extended pump life, No screen to interfere with flowing debris, Entire unit is pressure tested after assembly. I found it running with no water in the pit,unplugged it and moved the float up and down a few times and plugged it back in, and it is working okay now. The Zoeller M53 is and has been a great pump for many years! I have a Zoeller M53 1/3 hp sump pump. In that case, your best defense is a higher output.
These accessories are required to properly setup/install this product. I currently have a 1/3HP pedestal pump discharging through a 1-1/4" pipe. Thank you. I need to buy a generator, so I'm trying to determine what size. Get expert advice and be the first to hear about new products and special promotions. If water has seeped into the switch housing, this would certainly compromise the performance and safety of the pump and I would highly recommend replacing the pump. Should the switch compartment of the M53 remain above the waterline or be watertight, because when i opened to determine if i should replace the switch a lot of water came out. Even with this air relief hole in the pump, it's still highly recommended that you drill a "weep" hole in your discharge pipe. I installed according to directions. below underside of concrete floor when the float activates. I plan to replace a non working Zoeller M53 in a recently purchased house with a new Zoeller M53. Introducing a submersible pump like the Zoeller model M53, should give you a quieter pump but it may very well cycle more frequently than your current 1/3HP pedestal. The only maintenance that is required is what all manufacturers recommend. Is there a big difference between the M53 and M98 when it comes to noise and cycle rate? When it gets water in the pit again, the airlock condition shows up.
The starting amps for the M53 are 25.9. I purchased a home with a zoeller sump pump already installed in the basement. While the Zoeller pumps are one of the better pumps out there, they are not very efficient. The main pump will be set to activate at about 12 inches of water and the secondary pump will be set to activate at about 14-16 inches of water in the event the main pump cannot handle the amount of water coming in. If that should happen, it's usually easier to have it serviced at a local authorized Zoeller service center or replace the pump. This water rushing into this trench will have sand mixed in. We are an online retail store that sells and ships many different brands of pumps all over the United States. 2) what is the recommended location for the new check valve? What locations in Anchorge sells your product. for safty, You are describing a fairly common application. The Pro Series model. If you must reduce the piping, I don't recommend that you go any smaller than 1-1/4". Drill the hole at a 45-degree angle so the hole is pointing toward the bottom of your sump basin. As with any question that I get on wiring pumps, I must refer you to the fact that all manufactures do state the following: Jim,
the float is free and clear, but will not kick on unless i just tap the arm. Zoeller 1050001 13 HP M53 Remote SinkDrain Pump System w Vertical Float Switch
The 2" discharge WOULD require an adapter for either pump discharge, but should help. When it rains, my pit fills up very quickly and the pump goes every 2-3 minutes. Hi there, I'm planning on using this pump and a Jackel sump basin ( or something like that) to move water from a "lake" in my diveway, about 50' horizontally to a flower bed. Is the switch stuck? Nestor Ho, Thank you for your interest in Sump Pumps Direct. If we get heavy rain in a short amount of time, then a heavy flow of water flows directly underneath our house and directly into the pool. It is designed to handle a maximum of 15 feet of vertical lift. I have a Zoeller M53 in a basement sump 24 in. Is the 1 inch pipe OK, or is it necessary to change to 1 1/2 inch pipes? Pump warranties vary from 1 year to 5 years depending on the pump and the manufacturer. When in doubt, you should contact a licensed electrician in your area. Get helpful tips and buying advice from our experts.\"}]},{\"URL\":\"pumps\\\/sump-pumps-on-sale.html\",\"displayText\":\"Specials\",\"sectionLinks\":{\"columns\":\"6\",\"linkItems\":[{\"URL\":null,\"imageURL\":null,\"displayText\":\"\"}]},\"subCategories\":[]}],\"USP\":[{\"URL\":\"stories\\\/482-How-To-Get-Free-Shipping-On-Sump-Pumps.html\",\"className\":\"icon-nav-usp-shipping\",\"displayText\":\"Free Shipping\"},{\"URL\":\"stories\\\/357-Top-Sump-Pumps-Worth-Bragging-About.html\",\"className\":\"icon-nav-usp-knowledge\",\"displayText\":\"Expert Knowledge\"},{\"URL\":\"stories\\\/1270-How-to-Finance-Your-Sump-Pump-Purchase.html\",\"className\":\"icon-nav-usp-financing\",\"displayText\":\"Financing\"}]}","siteLinkJSON":"{\"Resources\":{\"How to Library\":{\"href\":\"how-to-library.php\",\"title\":\"Sump Pumps Direct How-To Library\"},\"Product Reviews\":{\"href\":\"reviews.php\",\"title\":\"Customer Reviews on Sump Pumps Direct Products\"},\"Recommendations\":{\"href\":\"stories\\\/357-Top-Sump-Pumps-Worth-Bragging-About.html\",\"title\":\"Product Recommendations\"},\"Weekly Specials\":{\"href\":\"pumps\\\/sump-pumps-on-sale.html\",\"title\":\"Weekly Sump Pumps Direct Specials\"},\"Manuals\":{\"href\":\"stories\\\/396-How-to-Access-Old-Sump-Pump-Manuals.html\",\"title\":\"Manual Lookup\"},\"Service Centers\":{\"href\":\"stories\\\/416-How-to-Find-a-Service-Center-For-Your-Sump-Pump.html\",\"title\":\"Service Centers\"},\"Technical Support\":{\"href\":\"stories\\\/428-How-to-Find-Tech-Support-For-Your-Sump-Pump.html\",\"title\":\"Technical Support\"}},\"Account\":{\"My Account\":{\"href\":\"account.php\",\"title\":\"Login to My Account\"},\"Email Preferences\":{\"href\":\"https:\\\/\\\/www.powerequipmentdirect.com\\\/newsletter_removal.php\",\"title\":\"Email Preferences\"}},\"Customer Service\":{\"Help Center\":{\"href\":\"contact_us.php\",\"title\":\"Help Center\"},\"Return Policy\":{\"href\":\"returns.php\",\"title\":\"Return Policy\"},\"Shipping Policy\":{\"href\":\"stories\\\/518-How-to-Easily-Unload-a-Sump-Pump.html\",\"title\":\"Shipping Policy\"},\"Track Order\":{\"href\":\"ordertracking.php\",\"title\":\"Order Tracking\"},\"Accessibility\":{\"href\":\"stories\\\/1778-Our-Commitment-to-Accessibility.html\",\"title\":\"Accessibility\"}},\"About Us\":{\"Our Story\":{\"href\":\"https:\\\/\\\/www.powerequipmentdirect.com\\\/stories\\\/1982-How-We-Make-Buying-Technical-Products-Simple.html\",\"title\":\"Sump Pumps Direct's Story\"},\"Careers\":{\"href\":\"https:\\\/\\\/www.powerequipmentdirect.com\\\/stories\\\/1924-Job-Openings.html\",\"title\":\"Careers @ Power Equipment Direct\"},\"Newsroom\":{\"href\":\"newsreleases.php\",\"title\":\"Sump Pumps Direct News Center\"}},\"Contact Us\":{\"phone\":\"888-455-4682\",\"hours\":{\"0\":\"M-Th: 8-5 CST\",\"1\":\"Fri: 9-5 CST\",\"2\":\"Sat: Closed\",\"3\":\"Sun: Closed\"}}}","storeLinkJSON":"{\"Air Compressors Direct\":{\"href\":\"https:\\\/\\\/www.aircompressorsdirect.com\\\/\",\"title\":\"Air Compressors Direct\"},\"Chain Saws Direct\":{\"href\":\"https:\\\/\\\/www.chainsawsdirect.com\\\/\",\"title\":\"Chain Saws Direct\"},\"Chippers Direct\":{\"href\":\"https:\\\/\\\/www.chippersdirect.com\\\/\",\"title\":\"Chippers Direct\"},\"eComfort\":{\"href\":\"https:\\\/\\\/www.ecomfort.com\\\/\",\"title\":\"eComfort\"},\"Electric Generators Direct\":{\"href\":\"https:\\\/\\\/www.electricgeneratorsdirect.com\\\/\",\"title\":\"Electric Generators Direct\"},\"Leaf Blowers Direct\":{\"href\":\"https:\\\/\\\/www.leafblowersdirect.com\\\/\",\"title\":\"Leaf Blowers Direct\"},\"Log Splitters Direct\":{\"href\":\"https:\\\/\\\/www.logsplittersdirect.com\\\/\",\"title\":\"Log Splitters Direct\"},\"Mowers Direct\":{\"href\":\"https:\\\/\\\/www.mowersdirect.com\\\/\",\"title\":\"Mowers Direct\"},\"Power Equipment Direct\":{\"href\":\"https:\\\/\\\/www.powerequipmentdirect.com\\\/\",\"title\":\"Power Equipment Direct\"},\"Pressure Washers Direct\":{\"href\":\"https:\\\/\\\/www.pressurewashersdirect.com\\\/\",\"title\":\"Pressure Washers Direct\"},\"Snow Blowers Direct\":{\"href\":\"https:\\\/\\\/www.snowblowersdirect.com\\\/\",\"title\":\"Snow Blowers Direct\"},\"Sump Pumps Direct\":{\"href\":\"https:\\\/\\\/www.sumppumpsdirect.com\\\/\",\"title\":\"Sump Pumps Direct\"},\"Water Pumps Direct\":{\"href\":\"https:\\\/\\\/www.waterpumpsdirect.com\\\/\",\"title\":\"Water Pumps Direct\"}}","socialLinkJSON":"{\"Facebook\":{\"href\":\"https:\\\/\\\/www.facebook.com\\\/SumpPumpsDirect\",\"icon\":\"icon-facebook\",\"title\":\"Facebook\"},\"Twitter\":{\"href\":\"http:\\\/\\\/twitter.com\\\/sumppumpsdirect\",\"icon\":\"icon-twitter\",\"title\":\"Twitter\"},\"Pinterest\":{\"href\":\"http:\\\/\\\/pinterest.com\\\/sumppumpsdirect\\\/\",\"icon\":\"icon-pinterest\",\"title\":\"Pinterest\"},\"YouTube\":{\"href\":\"http:\\\/\\\/www.youtube.com\\\/SumpPumpsDirect\",\"icon\":\"icon-youtube\",\"title\":\"YouTube\"},\"Instagram\":{\"href\":\"https:\\\/\\\/www.instagram.com\\\/powerequipmentdirect\\\/\",\"icon\":\"icon-instagram\",\"title\":\"Instagram\"},\"LinkedIn\":{\"href\":\"https:\\\/\\\/www.linkedin.com\\\/company\\\/power-equipment-direct\\\/\",\"icon\":\"icon-linkedin\",\"title\":\"LinkedIn\"}}","miscLinkJSON":"{\"Manufacturer Login\":{\"href\":\"https:\\\/\\\/www.powerequipmentdirect.com\\\/partnerships\\\/login.php\",\"title\":\"Manufacturer Login\"},\"Terms of Use\":{\"href\":\"terms-of-use.php\",\"title\":\"Terms of Use\"},\"Privacy Policy\":{\"href\":\"privacy.php\",\"title\":\"Privacy Policy\"},\"CA Privacy Rights\":{\"href\":\"privacy.php#californiaPrivacyRights\",\"title\":\"CA Privacy Rights\"},\"copyright\":\" 2022 Power Equipment Direct. Can you please assist me. These check valves should help reduce the "thumping" sound if they don't eliminate it all together. My pit is 15" across by 24" deep. If that is not visible, you can measure the height of the pump. Yes, you can, but you need to purchase it direct from Zoeller. Do I have to replace the pump?
What size generator would I need to run both of these during a storm? Regarding your cycle rate, it may actually increase since it will be emptying your basin quicker. You might try to brace and/or pad any area of the discharge pipe that may be coming in direct contact with any walls, ceilings or joists to try to reduce the vibration that is being caused by the sudden reversal of the water flow once that pump switches off and that check valve slams shut. The zoeller M53 unit is approximately 3 years old. This is true in sump and sewage applications.
I am torn between which Zoeller pump would be best for my application. The beach house we purchased sits on stilts with all concrete drive-thru underneath. I'd prefer to bypass the switch altogether but not if the compartment can't be sealed properly. Product Video Disclaimer: "PED is not responsible for any variances from the product in this video and the item you purchase. How To Pick The Perfect Pedestal Sump Pump. The pump runs due to the float switch being raised, but can't eject the water because of the airlock condition. You would really need to know the starting amp rating for your ice box to get an accurate number to size your generator. deep. The compressors on the icebox always require more amperage or power to start because of the extra torque needed. Pedestal sump pumps sit on a pedestal that keeps them out of the water. I want to replace it and was looking at this pump because my existing one is old and noisy. It leaves dirt all across our front yard and underneath our house, both of which are concrete. This is completely normal. Is there a difference between the m53-d mighty mate and the m53. Typical installations will include the discharge PVC Sch40 pipe screwed into the pump discharge port and extending approximately 2-3 feet above the sump basin cover. every hour for maybe 5 seconds max. Thanks,
I noticed that the zoeller 1/3hp pump takes 25 amps to start do I need a thirty amp circuit to run a zoeller pump? All is operating well - Leading up to a question, I think I am getting some water hammer. Unlike Born, raised, and built in the U.S.A., Goulds Water Technology is an American m You'll hardly think about your sump pump until it's too late. My concern is that it will be going off even more often if I change to a submersible style pump because it sits lower in the pit. All Rights Reserved\"}","expertJSON":{"imageURL":"https:\/\/www.powerequipmentdirect.com\/images\/experts\/expert-main-10.png","href":"\/sump-pump-product-expert.php","title":"Contact Jim @ Sump Pumps Direct","expertName":"Jim","expertTitle":"Sump Pump Expert"},"bbbJSON":{"imageURL":"https:\/\/www.powerequipmentdirect.com\/images\/badge-bbb.png","imageAlt":"Better Business Bureau\u00ae","href":"http:\/\/www.bbb.org\/chicago\/business-reviews\/industrial-equipment-and-supplies\/power-equipment-direct-in-bolingbrook-il-57001088","title":"Sump Pumps Direct - A+ Rating - Better Business Bureau\u00ae"},"zipCode":null,"phoneNumber":"888-455-4682","loginToken":"bc937ff5da63b36ffbaeaf02c81b7fd5d7d9f37afcaec14869a97f2b9e909a98","iterable":"e4b27e68b9c84fbb940829a0a9ee29d7","newNav":true}. I was planning to go about half way up the vertical pipe. What kind of draw (startup and normal operation) should I include in my calculations for sizing the generator. Oil should NOT need to be added at any time unless the pump develops a leak which is pretty rare. I cut a trench 2' wide X 1.5' deep into the concrete running the width of the house,45' and placed the M53 sump pump at the end. Note, in hurricane Irene my pump was going off every minute. Would this pump be suitable for a 12' x 12' basement? All the terminals are corroded so it's been running like this for some time. I can tell you that most average sized homes in an average water table area can usually get away with a 1/3HP or 1/2HP pump. An air relief hole in the base portion of the pump to help prevent air lock within the pump. Thank you,
That being said, you can make the call on weather you would like to replace the pump or the. There is a rubber gasket between the switch housing and pump housing that form a water-tight seal to protect the switch connections. Do you still need to drill an air relief hole in your pipe if this pump has an air relief hole? My pump keeps running, is it the switch or the pump? Regarding the noise concern, there should not be any difference as long as the pump is installed properly.
Zoeller pumps are known to last but are also known for some switch problems. I see there are two white plugs on the pump and I'm wondering if oil needs to checked or added periodically or any other type of maintenance is needed. Reducing it further will only create more backpressure on the pump which will reduce the pump life, not to mention the reduction in pumping capacity that you would realize. Can it be replaced? The M53 runs at 9.6 amps and requires 25.9 amps to start. We do carry other brands that will also be compatible with your pump and are capable of pumping more if you feel you need it. It has a 1.25" Pvc discharge pipe tying into 4" pipe that carries the water into a lake behind our home. I gave it a good rap, but to no avail. How far will this pump move the water? Some are more efficient than others. What am I expected to put between the pump body and the bottom clamp of this check valve? Thanks, Jim. Air locking on a sump pump happens when there is air between the pump and the check valve of the discharge line. When using the formula of amps X volts = watts, you would need a minimum 1152 running watts and 3108 starting watts to operate your pump. It has been running well, but now it will not come on. You might try looking at our listing of manufacturer contact. You don't want to just install a 3/4HP or 1HP pump just for the sake of it. I would like to know how many watts a 1/3 or 1/2 hp sump pump has, because i was think of buying a portable generator in case the power goes off. Would this pump work, and also be one that can handle the sand that comes in mixed with water? I have cleaned the pump, well and float. The pump is about 6 years old, should i replace it or is there something else i can do. Without knowing more specifics like the water table, area of the country you live in, actual square footage of your basement, etc., it really is difficult to answer. Other than that, both pumps are the same. Thank you for your interest in Sump Pumps Direct. Thereby cycling only maybe only every two hours. As the water level rises so does the float which, at some point, it will trigger the switch to turn the pump on. Should I buy the 507 or 510? Amps times volts give you watts. That would tell you exactly what size generator you would need to run both appliances at the same time. That being said, all pumps should last a good 5-7 years or more providing they are installed properly. The minimum sump basin size relates to the minimum size of your sump basin or pit, that a specific pump will safely operate in. The switch on the Zoeller M53 has about a 4 1/4" differential so by raising your pump in your basin, you will effect the level at which the pump will activate, however you will NOT effect how much water is pumped out. i have 1 zollerm53 if it stops iam done. wanting to buy a battery backup system for the M 53 . *We currently CANNOT ship this product to Canada or any destination outside of the United States, Zoeller M53 - 1/3 HP Cast Iron Submersible Sump Pump w/ Vertical Float Switch. The "D" series was manufactured between 7/92 and current. Thank you for your interest in Sump Pumps Direct.
The water is only on one side of the basement and never comes up on the other. It really depends on how you plan on getting the water into the sump basin. If you are doing a typical basement, I have a Zoeller sub pump 1198 horizontal install, I would like to buy another pump,where this one is quite old.
- Reflection And Clarity Candle
- Disney Cuties Mystery Pin Pack
- Black And White Striped Pants H&m
- Silver Plated Dragon Head Cane
- Xometry Injection Molding
- Hampton By Hilton Alexanderplatz Email
- Antique Crucifix Necklace
- Burnt Orange And Green Wall Art
- Ansi Vertical Turbine Pump